BMW F650 Forums banner
belt
1-20 of 24 Results
  1. Sale - Wanted - Swap (UK Only)
    I have two used drive belts for F650CS Scarver in very good condition (mileage unknown): 1x p/n 27 72 7 659 995 for up to 03 1x p/n 27 72 7 682 887 for 04 onwards These were spares I accumulated for my Scarver, which has now, unfortunately, been written off.:( £80 each belt posted to UK.
  2. F650 Single Discussion
    I bought a 2004 Scarver as a commuter bike - brilliant!!! Handles like a 250 but easily pulls to 90 mph, sorry, 70 mph! BUT, I just had a catastrophic failure of the rear belt sprocket. Close examination shows it was worn out. So, I need a rear sprocket and a front sprocket. The belt...
  3. Sale - Wanted - Swap (UK Only)
    Looking for a second hand F650 drive belt, Thanks, Patrick
  4. F650 Single Discussion
    A few weeks ago my CS drive belt went heading up towards hamstead. :doh: I walked up and down trying to find it, but I don’t know where it went unfortunately, as I would have liked to see the condition it was in. I guess it had done 35-40k, not sure as there was a clock change at some point...
  5. F650 Single Discussion
    Hi, I have just got a new belt fitted and it is makeing allot of noise. I have only gone 2 miles but it sounds like it is rubbing. I have checked it and it dosen't seem too tight (I don't have a center stand so can't check it properly, but I am baising it on this...
  6. F650 Single Discussion
    I have a 2004 F650CS. At the rear end of the swing arm, either side of the adjuster screw are two pinch bolts. These seem to periodically work loose. The first time I noticed this was after a 2500 mile trip abroad, when one bolt fell out. The bike had it's 12000 mile service prior to the trip...
  7. F650 Single Discussion
    Any advise from the CS owners out there? In the last week my bike has got coverd in brown dirt, so much so my wife thought my exaust had gone rusty in the road salt, until I wiped it off with my hand, so I'm going to clean it tomorrow. Anyway, what I was wondering was, is there anything I...
  8. F650 Single Discussion
    Hi all, The other day when traveling home on the motorway had a nasty surprise...I was in the outside lane overtaking traffic when I lost rear drive but still the engine was running...Managed to get across the two lanes of traffic and onto the hard shoulder...After looking around the bike found...
  9. F650 Single Discussion
    I have a 2004 F650CS which has done 12000 miles and has a hole in the belt drive. Looks like a stone has picked up on the pulley wheel and punctured a small hole in the belt. It's not a distinct hole, the material has been pushed up and punctured. It's about 2mm wide and fairly central on the...
  10. F650 Single Discussion
    Guys, working on an F650CS, 2003, belt drive. How is the belt tension adjusted ? Though it's already a low seat model, we need to lower it even more for a very short rider. I'm thinking this means longer links between the triangular pivot at the bottom of the shock and the swinging arm. Anyone...
  11. F650 Single Discussion
    :think: I have read all the posts about belt adjustment, thanks to all who have posted on the subject before. But my question is, what size torx fitting do i need to both slacken the lock screws and the belt adjuster screw? Going to tackle task on saturday, all help gladly received :-D
  12. F650 Single Discussion
    Having snapped my belt drive this morning, luckily about 20m from my house! I now need to replace the belt and whilst at it I thought that I would replace the rear tyre which has a temp repair plug in it. My questions are; Does a normal socket fit the rear wheel nut which according to the manual...
  13. F650 Single Discussion
    Do you need new pulleys to go with a replacement belt? BMW Berlin say you do, without checking. But then, the front costs €470 and the rear €140... Close to €1,000 simply for a belt change... Of course, they would say that if they were more concerned with how much they could earn off of you...
  14. F650 Single Discussion
    :think: Can anyone tell me were to find info on adjusting the belt drive on my cs. I have downloaded the repair manuel from the link on this site and the section in question is missing. Is that a cunning plan by BMW to keep said info out of the hands of us DIY mechanics, or have i missed...
  15. F650 Single Discussion
    Just rang BMW dealer in Southport about the cost of the tools for adjusting the belt tension on the cs (the measuring device and the suspended weight) they say they are not available and would cost over £300! is there a easier method of doing this yourself or do you have to go to a BMW dealer...
  16. F650 Single Discussion
    I know this may sound ridiculus, but is it possible to change a chain and sprocket kit for a belt drive.
  17. F650 Single Discussion
    I could do with some help on checking and if necessary, adjusting the belt on the CS. Could anyone send me a reply in English that a girly can understand and use? :dance:
  18. F650 Single Discussion
    Praise be for the glorious summer weather that we've now got, but it's causing me a problem :doh: New Hein Gericke "Air" summer clothing is working well at keeping me cool, but the trousers have no elastic in the waist band, just belt loops. Anyone know where I can get a suitable textile...
  19. F650 Single Discussion
    Hi I am a prospective F650GS owner and have been reading postings on chain lube etc and wondered has anyone tried to fit an F650CS Scarver belt drive to an F650GS?. Can the F650GS swing arm, wheel, final drive cover etc. be modifiied to accomodate belt drive components from F650CS...
  20. Get-Togethers, Meets and Ride-Outs
    Any ride outs in Scotland central belt? Jim
1-20 of 24 Results
Top